Skip to main content
U.S. flag

An official website of the United States government.

Petition - Docket No. 2003-022-C

Petition for Modification


In the matter of
HB Coal Co., Inc.
No. 1 Mine
ID No. 15-18606
Docket No. M-2003-022-C
30 CFR 75.380(f)(4)(i

PROPOSED DECISION AND ORDER


On March 12, 2003, a petition was filed seeking a modification of the application of 30 CFR 75.380(f)(4)(i) to Petitioner's No. 1 Mine located in Whitley County, Kentucky. The Petitioner alleges that the proposed alternative method will at all times provide the same measure of protection as the standard. 

MSHA personnel conducted an investigation of the petition and filed a report of their findings and recommendations with the Administrator for Coal Mine Safety and Health. After a careful review of the entire record, including the petition and MSHA's investigative report and recommendation, this Proposed Decision and Order (PDO) is issued. 

Finding of Fact and Conclusion of Law


The alternative method proposed by the Petitioner (as amended by the recommendations of MSHA) will at all times guarantee no less than the same measure of protection afforded the miners under 30 CFR Part 75.380(f)(4)(i). 

The Petitioner claimed that fire suppression technology is not available to fit the equipment being used in its mining height. MSHA previously confirmed the validity of this claim. There are no fire suppression systems on the market, from any supplier, for equipment operated in coal seam heights averaging 25 inches or less. The smallest canister manufactured is 18 inches. Therefore, mounting this canister on this small frame height equipment would not be practical. 

The Mescher tractors are driven in and out of the mine in the primary intake escapeway usually twice per shift for mantrip purposes (beginning and end) and a low number of times to haul supplies to the section or to have their batteries exchanged. The Mescher tractors are used in the outby areas of the mine to transport personnel and supplies. On the working section, the tractors are also used to transport coal from the working face to the dumping point. Title 30 CFR Part 75.380(f)(5)(ii) permits battery powered personnel carriers and small mobile equipment designed and used only for carrying people and small hand tools to operate in the intake escapeway with 2-10 lb fire extinguishers and not a fire suppression system. These tractors do not meet 30 CFR 75.380 (f)(5)(ii) definition of “small mobile equipment”, but are battery powered and have no hydraulics. Therefore, the tractors have the same type of fire source (96 volt batteries) as the “small mobile equipment” referenced in 75.380(f)(5)(ii). The investigation report revealed that the Mescher tractors do not have a fire history. 

On the basis of the petition and the findings of MSHA's investigation, HB Coal Co., Inc., is granted a modification of the application of 30 CFR 75.380(f)(4)(i) to its No. 1 Mine. 

ORDER


Wherefore, pursuant to the authority delegated by the Secretary of Labor to the Administrator for Coal Mine Safety and Health, and pursuant to Section 101(c) of the Federal Mine Safety and Health Act of 1977, 30 U.S.C., sec. 811(c), it is ordered that HB Coal Co., Inc.'s, Petition for Modification of the application of 30 CFR 75.380(f)(4)(i) in the No. 1 Mine is hereby: 


GRANTED, for Mescher three wheel tractors to be operated in the primary intake escapeway conditioned upon compliance with the following terms and conditions:

1. Each tractor shall be provided with a total of 20 pounds of multipurpose dry chemical, in any combination of 5 pound or 10 pound portable fire extinguishers; 

2. Ten pounds, either two 5 pounds or one 10 pound, of the total 20 pounds multipurpose dry chemical extinguishment shall be mounted in the deck of the Mescher tractor and be readily accessible by the operator; 

3. Fire extinguishers required in stipulation No. 1 shall be inspected daily by the equipment operator prior to the tractor entering the primary intake escapeway; 

4. The tractors shall be battery powered with no hydraulics; 

5. All tractors shall be maintained in a permissible condition; and 

6. Within 60 days of the PDO being granted, the Petitioner shall submit proposed revisions for its approved 30 CFR 48 training plan to the MSHA's District Manager. These proposed revisions shall include initial and refresher training regarding compliance with the PDO.

Any party to this action desiring a hearing on this matter must file in accordance with 30 CFR 44.14, within 30 days. The request for hearing must be filed with the Administrator for Coal Mine Safety and Health, 1100 Wilson Boulevard, Arlington, Virginia 22209-3939. 

If a hearing is requested, the request shall contain a concise summary of position on the issues of fact or law desired to be raised by the party requesting the hearing, including specific objections to the proposed decision. A party other than Petitioner who has requested a hearing shall also comment upon all issues of fact or law presented in the petition, and any party to this action requesting a hearing may indicate a desired hearing site. If no request for a hearing is filed within 30 days after service thereof, the Decision and Order will become final and must be posted by the operator on the mine bulletin board at the mine.

 

 

_________________________________

John F. Langton
Acting Deputy Administrator
 for Coal Mine Safety and Health